Date:
MSDS No.:
1/5/2009
CAN-F27
Trade Name:
Sizes:
MIL 800 HPNi
---
9/10/2007
Supersedes:
M A T E R I A L S A F E T Y D A T A S H E E T
For Welding Consumables and Related Products
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
Section I & II - Preparation and Product Information
Product Type:
Representative Classifications:
Submerged Arc Flux
AWS F8A6-ENi1K-G-H2
F9A4-ENi5-G-H2
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
Section III - Hazardous Ingredients (1)
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed.
(1)
The term “hazardous” in “Hazardous Ingredients” should be interpreted as a term required and defined in the Hazardous Products Act and does
not necessarily imply the existence of any hazard.
TLV
LD50
LC50 mg/m3
Ingredients:
CAS No. Wt. % mg/m3 (Route/Species) (Route/Species)
Magnesite
1309-48-4
1344-28-1
7789-75-5
1332-58-7
1344-09-8
7439-96-5
7440-02-0
7440-21-3
14808-60-7
7439-89-6
14464-46-1
7440-62-2
30-60
10-30
10-30
10-30
5-10
10
10
Not Available
Not Available
4250 mg/kg
(oral/rat)
Not Available
Not Available
Not Available
Not Available
Aluminum oxide and/or Bauxite
Fluorides (as F)
2.5
590 g/kg LDLo
(oral/rat) reproductive
1153 mg/kg
Mineral silicates
5**
Silicates and other binders
Manganese and/or manganese alloys and compounds (as Mn)
Nickel (metal)
10*
Not Available
2.3 LCLo
(inhalation/human)
(oral/rat)
9 g/kg
(oral/rat)
1-5
0.2
50 mg/kg LDLo
(intravenous/mouse)
1-5
1.5
Not Available
Silicon and/or silicon alloys and compounds (as Si)
Quartz
0.1-1
0.1-1
0.1-1
0.1-1
0.1-1
10*
Not Available
200 mg/kg LDLo
(intratracheal/rat)
Not Available
300 LCLo
(inhalation/human)
#0.05**
10*
Iron
Not Available
10,000 mg/kg
(oral/rat)
10 mg/kg LDLo
(oral/rat)
Not Available
Crystalline-Silica (cristobalite)
Vanadium alloys (as V)
#0.025**
.05(@)
Not Available
346 mg LCLo
(inhalation/human)
Notes:
(LDLo, LCLo) Lowest published toxic concentration.
(*)
Not listed. Nuisance value maximum is 10 milligrams per cubic
(#)
Crystalline silica (quartz) is on the IARC (International
Agency for Research on Cancer) and NTP (National
Toxicology Program) lists as posing a carcinogenic risk to
humans.
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(**)
(@)
As respirable dust. Value for respirable quartz is 0.1 milligrams
per cubic meter.
As V 0 fume or dust.
2 5
Section IV - Physical Data
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to this product and
its use.
Section V - Hazard Data
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in Section VIII.
Product is inert, no special handling or spill procedures required.
Rev 9/07
(CONTINUED ON SIDE TWO)
|